Volkswagen Passat Heater Core Replacement The Fast Way Youtube 2015 volkswagen passat heater core replacementif you would like to help support this channel please take a look at these tools i recommend and use daily. str. On amazon:*heater core: amzn.to 2ukiar9*torx drivers: amzn.to 2unouh2*mechanics tool set: amzn.to 2nctgic*note: when i made this vi.
2015 Volkswagen Passat Heater Core Replacement Youtube Here is a video tutorial on how to remove replace or install heater core on vw passat b6, b7, cc, golf 5, 6, golf 7, tiguan, touran, cc, caddy, skoda octav. The foot vent can be removed after the panel it has a few torx screws. this panel covers the heater core. 4 screws remove it. the core exposed. remove the clamps and pull the lines apart. this was the hardest part. the manual tells you to loosen the 6mm screw that is in between the heater core lines under the hood. December 2020 no heat passenger side. under the special extended diesel warranty to 125k miles they replaced the radiator, oil cooler, tranny oil cooler, diesel cooler, flushed the engine, replaced every pipe and hose and of course the heater core. over $10,000 of work for free. december 2022 no heat passenger side again. I hear you on the cost of oem, but i just wasn't ready to put another core with plastic pipes in my car. so, i found an all metal oem version for about $185 (8d1 819 031 c) from vw part world (they are a dealer out of washington state). by the way, i've been collecting all the videos and write ups on it as i can find.
2013 2014 Passat Tdi Heater Core 2 0l Springfieldvw December 2020 no heat passenger side. under the special extended diesel warranty to 125k miles they replaced the radiator, oil cooler, tranny oil cooler, diesel cooler, flushed the engine, replaced every pipe and hose and of course the heater core. over $10,000 of work for free. december 2022 no heat passenger side again. I hear you on the cost of oem, but i just wasn't ready to put another core with plastic pipes in my car. so, i found an all metal oem version for about $185 (8d1 819 031 c) from vw part world (they are a dealer out of washington state). by the way, i've been collecting all the videos and write ups on it as i can find. Finally tracked the leak down. there was a coolant leak by the gas pedal where the heater core pipes go into the pipes that pass through the firewall. the pipes that pass through the firewall have damaged flanges, also part of the lower plastic cover is broken. looks like the previous owner damaged some things when replacing the heater core. This is probably one of my worst videos being that i lost the last clip i ended up not pulling out the heater core because it was the blend door so i "fixed.
Vw Cc Air Conditioner Intake Ac Compressor Control Solenoid Valve For Finally tracked the leak down. there was a coolant leak by the gas pedal where the heater core pipes go into the pipes that pass through the firewall. the pipes that pass through the firewall have damaged flanges, also part of the lower plastic cover is broken. looks like the previous owner damaged some things when replacing the heater core. This is probably one of my worst videos being that i lost the last clip i ended up not pulling out the heater core because it was the blend door so i "fixed.
Comments are closed.