How To Replace Volkswagen Passat B6 Transmission Intercooler

How to replace volkswagen passat b6 transmission intercooler. how to replace volkswagen passat b6 transmission intercooler. Remove 4 square screws that hold hard line to t stat housing. one is just right of oil filter, the other is on the right side of the engine just above one of the trans bellhousing bolts. these are a pita. remove screws from t stat housing. a long 1 4 drive with a wobble extension and a 4 square bit worked the best.

Bmw. ford. audi. peugeot. nissan. illustrated step by step manuals and video tutorials on replacing vw passat intercooler will tell you how to carry out diy replacement of parts and maintenance of your car quickly and cheaply. Banged up is not a problem as long as it's airtight and the fins aren't too bad. filling with oil is not good, not an intercooler problem it's a turbo or other problem. a handful or dribble of oil is normal since oil will settle in low spots, more than half a cup is when i would get worried. too much oil = usually bad turbo and possible engine. Reinstall the transmission pan fill level tube (red thing). now put your fluid injection kit together, connect the hose adapter to the transmission pan drain hole, give the garden sprayer about 10 good pumps and watch the magic happen. all of the fluid will be injected in a couple of minutes. So, i decided to change my transmission fluid and record my results on video. the fluid i'll be using is castrol syntrax limited slip 75w 90 synthetic gear oil. i'm using is oil because other than the 30 dollar vw audi fluid that is really expensive, this one was recommended choice after that. i also will display the color of the transmission.

Reinstall the transmission pan fill level tube (red thing). now put your fluid injection kit together, connect the hose adapter to the transmission pan drain hole, give the garden sprayer about 10 good pumps and watch the magic happen. all of the fluid will be injected in a couple of minutes. So, i decided to change my transmission fluid and record my results on video. the fluid i'll be using is castrol syntrax limited slip 75w 90 synthetic gear oil. i'm using is oil because other than the 30 dollar vw audi fluid that is really expensive, this one was recommended choice after that. i also will display the color of the transmission. B6 passat 09m 6speed automatic. drained 3 liters from the transmission before dropping the pan. replaced the filter and pan gasket. filled with 6 liters of fluid. should take 5.5 liters with filter change ,7 liter capacity. overflow plug is in but it drained 2 liters of fluid before dripping. trans 95 113f engine running in park. 17 posts · joined 2012. #1 · feb 3, 2016. ok, so my 06 passat w 3.6 has been throwing the 000022 bank 1: cmp sensor (g40) engine speed sensor (g28) p0016 008 incorrect correlation mil on periodically since about 180,000 miles. its now at 195,000 and i decided to finally replace the timing chains and oil pump bolt as i'm fair sure.