2013 2014 Passat Tdi Heater Core 2 0l Springfieldvw Is your volkswagen passat, audi a4, a6, or a8 failing to put heat out from the heater core at idle, or completely?if your vw or audi has no heat, due to a cl. I found the best to way to remove and replace the heater core in a volkswagen b5 passat. the first time i replace one it was very hard and frustrating, i dis.
Volkswagen Passat Heater Core Replacement The Fast Way Youtube This is a video of us replacing the heater core on a 2002 volkswagon passat. 04 passat 1.8t gls variant manual swapped, 16 a4 s line sport pkg prem , 2017 q5 prem , 07 jetta 2.5, 2015 beetle classic 1.8t previous: 2000 b5 sedan 1.8t, 2013 cc sport dsg, 1998 jetta k2 2.0, 2015 passat tdi selp. The previous owners mechanic of this 2005 v6 mixed pink and green anti freeze and the whole system gummed up. it was only an intuition that i bypassed the heater core when using the chemical flush. within 2 minutes of the introduction of the flush solution the radiator sprung leaks everywhere necessitating replacement. 4. watch out, there is a connector above the gas pedal that i don't think is shown in the vid. almost pulled the wires out of the plug before i realized it was missed. 5. loosen the nut on the steering rod u joint clamp bolt not the torx screw side. then use a pry bar to pop the bolt out.
Heater Core Flush Wth Is This Volkswagen Passat Forum The previous owners mechanic of this 2005 v6 mixed pink and green anti freeze and the whole system gummed up. it was only an intuition that i bypassed the heater core when using the chemical flush. within 2 minutes of the introduction of the flush solution the radiator sprung leaks everywhere necessitating replacement. 4. watch out, there is a connector above the gas pedal that i don't think is shown in the vid. almost pulled the wires out of the plug before i realized it was missed. 5. loosen the nut on the steering rod u joint clamp bolt not the torx screw side. then use a pry bar to pop the bolt out. The foot vent can be removed after the panel it has a few torx screws. this panel covers the heater core. 4 screws remove it. the core exposed. remove the clamps and pull the lines apart. this was the hardest part. the manual tells you to loosen the 6mm screw that is in between the heater core lines under the hood. Thanks for all this. i have 04 passat 1.8 gls 4 motion. changed thermostat flushed system and no heat and it boiled over. i flushed the heater core and then reversed the flow to make sure good flow both ways, filled heater core with 50 50 g12 and distilled water.
Early Results From Flushing 2003 B 5 5 V6 Passat Heater Core Youtube The foot vent can be removed after the panel it has a few torx screws. this panel covers the heater core. 4 screws remove it. the core exposed. remove the clamps and pull the lines apart. this was the hardest part. the manual tells you to loosen the 6mm screw that is in between the heater core lines under the hood. Thanks for all this. i have 04 passat 1.8 gls 4 motion. changed thermostat flushed system and no heat and it boiled over. i flushed the heater core and then reversed the flow to make sure good flow both ways, filled heater core with 50 50 g12 and distilled water.
Flushed Heater Core Today Volkswagen Passat Forum
Comments are closed.