Replacing Transmission Cooler Lines Vw Passat Youtube Axenstar said: those lines are extremely difficult to put back. be careful not to trash o rings inserting the lines in the radiator. yup. that is one reason why i prefer to have confirmed right o rings. "close enough" will either leak, or make it even worse to put back on. axenstar, andreaspassat and cchief22. The transmission cooler lines are held with a screw at each line. remove the screws and pull the lines out. it might take some effort to get them out if your car has a lot of miles, but it's not too difficult. those lines have o rings so plan on replacing those.
Replacing Oring Seals For Transmission Lines Youtube Any tips would be much appreciated. i might also try disconnecting the top line, getting the lower line in place, then going back to the top line. i can't remember ever having a real problem reattaching those lines. since there is only one bolt, i wouldn't recommend using a longer bolt to do anything but line it up. Please watch: "mercedes benz s430 installing front air struts" watch?v=klemkqjlbe0 ~ replacing transmission cooler lines on my 200. Removing and installing page 19 22 after replacing, completely replace coolant with atf cooler on vehicles with automatic transmission: clean atf cooler. 2 securing pin 3 securing rubber. 19 4. 4 connecting piece for atf line. only for vehicles with automatic transmission. 5 upper coolant hose. Actually there is one o ring on the top of each bolt (small and fat), and one o ring (large but skinny) under the cooler at each bolt. so you'll have to pull the cooler off to change the lower two. auto trans fluid change or flush will not make a trans fail. stop spreading the wives tale urban myth.
Volkswagen Passat Variant 2001 2002 р рёрґрєрѕсѓс рѕрѕрµ рѕс р р р рґрµрѕрёрµ Vag Removing and installing page 19 22 after replacing, completely replace coolant with atf cooler on vehicles with automatic transmission: clean atf cooler. 2 securing pin 3 securing rubber. 19 4. 4 connecting piece for atf line. only for vehicles with automatic transmission. 5 upper coolant hose. Actually there is one o ring on the top of each bolt (small and fat), and one o ring (large but skinny) under the cooler at each bolt. so you'll have to pull the cooler off to change the lower two. auto trans fluid change or flush will not make a trans fail. stop spreading the wives tale urban myth. Feb 6, 2017. #13. while this is an old thread i thought it warranted a reply as a question got asked in the original post but was never fully answered. the part number and sized for the atf cooler o rings are: lower 089409069 (13 x 2.5 mm) upper 096409069a (13 x 3.5 mm) the cooler uses 2 of each. Genuine volkswagen part # 089409069 (089 409 069) seal ring. transmission cooler o ring. liter, oil, cooling. fits beetle, beetle convertible.
Comments are closed.